I just purchaced a 2014 Fusion in Sept. For the last 3-4 months I have had the 'check fuel fill inlet' message appear, sometimes with the check engine light and sometimes without. At the next opportunity, safely pull off the road, turn off the engine, open the fuel filler door and remove any visible debris from the fuel fill opening. I have already filled up twice and feel that this should be gone by now. The dealer just used the funnel from the trunk. I'm mechanically inclined and have some tools. If your spark plugs look good, problems with your ignition system can also preventing a spark.
All other company, product, or service name references on this site are used for identification purposes only, and are trademarks of their respective owners. Currently have 65K and the warning error seems to be lighting more often. Obd-ii trouble code: p0455 evaporative emission control, P0455 and p0442 on 2001 dodge ram 4x4 quad after attaching my scan tool i retrieved the dtc p0455 and p0442 which point to both a large and small evap systems leak. It is similar to and P0457 is normally not an immediate threat to the drive-ability of your Mondeo. However, I'm still getting the message.
If there is anything that you feel like you could add, please feel free to leave a comment below. Anybody had to pay for this repair out of pocket? It is also dificult to put fuel in, the pump keeps shutting off. I turned the engine off and then on again. The more trouble codes there are, the easier it can be to diagnose a problem. For others, air is an absolute must. After removing mine I could blow air through with my mouth.
Obviousily there is no gas cap to check. I would shove the funnel provided in the inlet, and after several driving cycles the message would go away. If the warning stays on or continues to turn on while the vehicle is running, contact your authorized dealer as soon as possible. Too many people with same problem, recall is order. How serious is the P0645 code? Code 455 is for a major leak, and code 457 is for the gas cap which could cause 455. Contact a Ford or Lincoln dealership to determine whether the Bulletin applies to your vehicle. The most recent information is available through Ford Motor Company's on-line technical resources.
If you are getting that message, plus a P0457, it may save you a ton of time and money to replace the fuel cap and see if it goes away. P0457 is a somewhat common trouble code with the Ford Mondeo. This may not happen right away — with some vehicles, it can take as many as eight failures before the is activated. Fusion P0457 Trouble Code Causes There are many things that can cause the P0457 trouble code to trigger in your Ford Fusion. Sometimes this is the more affordable option.
I have had the same error, but mine intermittently comes and goes since about 15K. Look for either a tear or hole in it. Remove the evaporative emission canister. Thanks in advance for your help! Stop the vehicle as soon as safely possible and turn off the engine. I got myself a small Bluetooth code reader and started watching the evap sensor and the behavior was erratic. I got the Check Fuel Inlet Message 2 weeks ago today after getting gas the previous night. Of course, after checking it, it seemed fine.
P0456, p0455, p0457 ford — ricks free auto repair advice, Diagnose and fix trouble codes p0456, p0455, p0457 on a ford ford has issued a service bulletin 11-11-28 to address a problem with the evaporative emissions system setting p0456, p0455, p0457 and other trouble codes. Had the same thing that went away after useing the the provided filler tube that is in the truck under the carpet, then resetting. Yes - Replace the evaporative emission canister. Fuel vapors are routed by hoses to a charcoal canister for storage. Each car maker uses a different techniques to check, but most often it's some type of fuel tank pressure sensor. I got a sneaky hunch that to rid ourselves of this annoying issue it is going to cost a lot of money. Do you think this could have led to this failure? I jammed the plastic funnel thing in there a bunch of times.
The on-board diagnostics system and engine control unit are in charge of monitoring a bunch of different, and if they get a reading that's a little out of whack, up pops the check engine light. Please let me know what this message is and how to remedy it. They can also give you an accurate estimate of any potential repairs. Sep 16, 2012 Both codes are for major leaks in the Evap system which vents fumes from the gas tank to the engine. I am new to this forum and have honestly never joined a car forum before. Why all the negativity, - someone only asked a maint question on a maint forum and gets flamed.